In many parts of life will use the ice machine, such as shaved ice drinks, seafood preservation ... ... that ice machine pump working principle, characteristics and precautions are what is it? Let's look at Xiaobian's solution! Ice machine First, the working principle of the ice machine water pump Chilled water pump continuous circulation through the plate or sub-grid evaporator; compressor operation by suction - compression - exhaust - condensation (liquefaction) - throttle - then endothermic vaporization in an evaporator at a low temperature of -10 to -18 ° C. Chilled water at 0 degrees of water temperature in the lower temperature evaporator surface condensation into ice. When the ice layer to a certain thickness, the evaporation temperature of the refrigerant reaches the set temperature of the temperature control, that is, connected to the defrost valve often use the form of heat pump deicing. Re-achieve the next cycle. Second, the ice machine pump features 1. Beautiful and elegant shape, all stainless steel design, durable, hygienic and easy to clean. 2. Special treatment of the front plate, not easily contaminated with oil. 3. Microcomputer detection control system, less failure. 4. High efficiency, high stability of the vertical evaporator, ice ice falling fast, saving time and electricity. 5. The storage ice bucket adopts the overall rotomolding (seamless) of PE, the thermal insulation performance is good and reaches the food grade standard. 6. Hexahedron easy to use, large contact surface, the beverage can quickly cool, taste better. 7. Fluoride-free foam compartment, with independent cleaning function, with adjustable balance feet. 8. Widely used in coffee SHOP, hotels, bars, KTV nightclubs, fast food restaurants and other food places. Third, the ice machine water pump Notes 1. Ice machine should be installed away from heat, no direct sunlight, good ventilation, the ambient temperature should not exceed 35 degrees Celsius, to prevent the ambient temperature is too high lead to poor condenser cooling , Affect the ice making effect. The floor of the ice machine to be installed should be solid and flat, and the ice machine must be level, otherwise it will cause no ice and noise during operation. 2. Ice machine to the back and left and right side of the gap not less than 30cm, the top of the gap is not less than 60cm. 3. Ice machine should use an independent power supply, green power supply and with fuses and leakage protection switch, but also to a reliable grounding. 4. Ice machine water to comply with national drinking water standards, and install water filtration device, filter impurities in the water, so as not to plug the water pipe, contaminated sink and ice mold. And affect the ice making performance. 5. When cleaning the ice machine should turn off the power, it is forbidden to use the water pipe to directly flush the body, use a neutral detergent scrub, acid, alkaline and other corrosive solvents are strictly prohibited. 6. The ice maker must unscrew the hose end of the hose for two months and clean the inlet valve strainer to prevent clogging of the inlet with sand and mud impurities in the water, resulting in a smaller amount of water and no ice. 7. The ice maker must clean the condenser surface dust every two months. Condensation can cause damage to the compressor components due to poor heat dissipation. Cleaning, the use of vacuum cleaners, small brush cleaning condensate surface oil, can not use sharp metal tools to clean, so as not to damage the condenser. 8. Ice machine water pipes, sinks, storage tanks and protective film to be cleaned once every two months. 9. When the ice maker is not in use, it should be cleaned and dried with a hair dryer to dry the ice mold and the water in the box, placed in a non-corrosive gas and ventilated and dry place to avoid open storage. Further Reading: pump valve pipe fittings Exhibition Water Expo Xiamen exhibition of marine equipment Internet + Forum Yiwu Fair 2016 exhibition mold top ten brands of the Internet information industry (Xiamen) Technology Co., Ltd. Author: Asian pumps Network Editor: Yao Xiaoxia (QQ / WeChat:) http://beng.liuti.cn/ (Service Hotline:)
Smart Floodlight,Smart Flood Light,Wifi Flood Lights,Smart Led Flood Light
Guangdong Smart Street Lighting Co., Ltd , https://www.fldlight.com